Government Contract | California

Bid Information

Bid Alert No: 00000408377


Agency Bid No. Title: RFB-IS-16200493

Received Date: 11/02/2015

Close Date: 11/16/2015

Purchase Type: Not Stated

Delivery Point: Los Angeles, California

Delivery Date: Not Stated

Special Notices: Bidder Preregistration


Specifications include, but are not limited to:1244 61st Street Los Angeles, CA 90001 General Discription:Material to be supplied to upgrade the pool mechanical room. 1. RayPak WH9-2002B High Delta Model CPN2072 Gas PooL Heater a. 1,999,000 BTU input rating b. Natural Gas c. 85% Thermal Efficiency d. Maximum Outlet temp. 210 e. PolyTuf Powder coated cabinet f. 3/4" hp inline bronze pump w/21/2" flange2. HEAT EXCHANGER a. Constructed of Brass b. Straight cupro nickel tubes w/integral fins spaced seven fins per inch c. Tubes terminate into one piece w/glass lined front header & bronze rear header d. Tested at 240 psi & approved for 160 psi e. Must bear ASME "HLW" stamp3. CONSTRUCTION a. Shall be rated for indoor or outdoor installation b. Cabinet and all internal parts to be stainless steel, galvanized or aluminized. c. Exterior cabinet is textured powder coat paint. d. CSA low lead certified .25Pb 4. BY-PASS a. Equipped w/factory by-pass assembly b. Shall include sealed bronze pump c. Constucted of 2 1/2" sch 80 CPVC w/brass inserts d. Automatic three-way valve 5. OPERATING CONTROLS a. 120v, 60Hz Power supply b. 120/24v 60Hz Transformer c. 100% Shut-off/lockout d. Hot surface Ignition e. Remote Flame Sensor f. High Limit Control, Manual Reset g. On/Off Power Switch h. Manual Shut-off, Front-Mounted i. Flow Switch j. Blocked Vent Pressure Switch k. Combustion Air Proving Switches l. Economaster Pump Time Delay m. Enable/Disable n. DIagnostics Panel with LCD Display 2 Lines, 20 Characters. 6. APPROVALS AND RATINGS a. Shall be approved by American gas Association w/ appropriate ANSI test standard. b. The unit shall bear the ASME stamp c. Heater must have laboratory rating for oxides of nitrogen(NOx) of less than 20ppm corrected to 3%O2 e. Heater shall be approved for indoor and outdoor installation f. Heater shall be approved for Sidewall, DirectAire Vertical, DirectAire Verticalw/sidewall Air inlet, DirectAire Horizontal, Aire-Lock Direct Vent and conventional venting g. Venting shall be classified category 1, negative draft, non-condensing, type B double wall, Direct Vent require AL29-4C 7. START UP AND INSTRUCTIONS A factory trained service technician will start up the swimming pool heater. Verification of adequate gas pressure as heater is firing, draft potential of vent system and electrical interlocks will be reviewed. Complete operating and service manuals with exploded parts diagrams shall be supplied with heater.WARRANTYThe complete heat exchanger assembly shall carry a five (5) year warranty against leakage. All other parts of the heater shall carry a one (1) year warranty. 8. California Code Control G-12 9. LMI Feed Pump a. Electronic metering chemical pumps b. Supplies 240 GPD, 80 PSI c. 120v d. Four Function valve 10. Chemtrol PC2100 Controller a. 8 line LCD display b. ORP/pH control c. Programmable shock treatment and chemical savings d. USB/Micro SD ports for updates e. Full screen menu f. Safety flow switch g. 110 volt acid/cholrine feed h. Sensor cell i. Made in USA 11. EPD 4" Backwash Valve 12" EPD 6" Backwash Valve 13. Mermaid 10" Lid 14. Mermaid 12" lid 15. LMI Tubing Kit for G Series Pump a. Includes: foot valve, anti-siphon, pressure relief, 15' tubing, ijection valve, four function valve-converts SD tubing to pump tubing. 16. Paragon Pump Pressure Booster System a. 1/2 HP pump and motor b. 115/230 VAC, 1 phase, 60 cycle 115 VAC operation w/pressure switch c. Hydro pneumatic tank d. Check valve assembly e. Tee assembly f. 100 feet of 3/8" tubing and all necessary tubing fittingsfor connection to the filter system.

Bid Related Documents

Download Document

Bid Related Attachments

Download Attachment

Product Code: 65066

Agency Information

Issuing Agency: County of Los Angeles

State: California

Agency Type: State and Local

Contact: Peter Genov ISD Central Purchasing, 1100 N. Eastern Ave. Room 103, Los Angeles, California, 90063

Phone: 323-267-2297



FREE Market Analysis

Get a FREE 90-Day Market Analysis and see the bids you’ve been missing